Husqvarna LTH135 User Manual Page 1

02478LTH135Owner's Manual01960_husqvarna

10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to

11OPERATIONThe operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safe

12OPERATIONTO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope.• Choose th

13OPERATIONPURGE TRANSMISSIONCAUTION: Never engage or disengage freewheel lever while the engine is run- ning.To ensure proper operation and performa

14FIG. 8 MOWING TIPS• Mower should be properly leveled for best mowing per-formance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments

15MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil

16MAINTENANCEBLADE REMOVAL (See Fig. 9)• Raise mower to highest position to allow access to blades.• Remove blade bolt, lock washer and fl

17MAINTENANCEV-BELTSCheck V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not ad just able. Re

18AIR FILTER (See Fig. 14)Your engine will not run properly using a dirty air fi lter. Replace pre-cleaner after every 25 hours of operation or every

19SERVICE AND ADJUSTMENTSWARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST MENTS:• Depress clutch/brake pedal fully a

2Safe Operation Practices for Ride-On MowersIMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE T

20SERVICE AND ADJUSTMENTSNUT "E""D""D"MANDRELFIG. 19NUT "F"FRONT LINKSFIG. 20BOTH FRONT LINKS MUST BE EQUAL IN

21FIG. 21SERVICE AND ADJUSTMENTS3842IDLERPUL LEYSMANDRELPULLEYMANDRELPULLEYTO CHECK AND ADJUST BRAKE (See Fig. 22)Your tractor is equipped with an ad

22SERVICE AND ADJUSTMENTSTRANSAXLE MOTION CONTROL LE VER NEUTRAL ADJUSTMENT(See Fig. 24)The motion control lever has been pre set at the factory and

23SERVICE AND ADJUSTMENTS01536HOODTO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 29)• Raise hood.• Unsnap headlight wire connector.FIG. 29HEADL

24STORAGEENGINEFUEL SYSTEMIMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ES SEN TIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL F

25Will not start 1. Out of fuel. 1. Fill fuel t

26PROBLEM CAUSE CORRECTION Engine continues to run 1. Faulty operator-safety presence control system. 1. Check

27TRACTOR - MODEL NO. LTH135 (HAU135H36B)SCHEMATICBATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITHEADLIGHTSREMOVABLECONNECTIONSBLACKBLACKBLACKWHIT

28REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)ELECTRICAL 2829262442432727254127274033903082127521616482221

29REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)ELECTRICALKEY PART NO. NO. DESCRIPTION1 532 16 34-65 Bat

3Safe Operation Practices for Ride-On MowersSAFETY RULES• Be sure the area is clear of other people before mow-ing. Stop machine if anyone enters

30REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)CHASSIS AND ENCLOSURES647410305157535254551729281220931129208209209552071442626602614426101422081

31REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)CHASSIS AND ENCLOSURES1 532 17 46-19 Chassis Stamping2 532 17 65-54 Drawbar, 12 G

32REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)DRIVE66292832305232593861415335553662353622393416177773052566465212631167057962625192426267678757

33REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)DRIVEKEY PARTNO. NO. DESCRIPTIONKEY PART NO. NO.

34REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)STEERING ASSEMBLY44515459577943324364381040118694646869247472630281414237363738123968676767136585

35REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)STEERING ASSEMBLYKEY PART NO. NO. DESCRIPTION1 532 16 66-

36KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTION1 532 14 08-39 Sea

37REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)DECALS10439KEY PART NO. NO. DESCRIPTIONKEY PART N

381 532 17 05-51 Control Th/ch Flag2 817 72 04-08 Screw Hex Thd Cut 1/4-20 x 1/23 - - - - - - - - Engine, B&S 31H777

39 1 532 15 94-60 Wire Asm Inner W/plunger LT 2 532 15 94-71 Shaft Asm Lift 3 532 10 57-67 Pin Groove 4 8

4PRODUCT SPECIFICATIONSGASOLINE CAPACITY 1.25 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE

40REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)MOWER DECK131110985334146148172171212121113123303030333217741221531168169222121216272625242328292

41REPAIR PARTSTRACTOR - MODEL NO. LTH135 (HAU135H36B)MOWER DECKKEY PART NO. NO. DESCRIPTIONKEY PART NO

4215 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

43SECTION 1: LIMITED WARRANTY Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original pur-chaser to be free

532 18 82-41 5.29.03 MHPrinted in U.S.A.01960_husqvarna

We hope you find the links below useful. For further gardening information visit www.GardenResources.co.uk Blower Vacs Brush cutters Bru

5UNASSEMBLED PARTSSteering WheelSteering Wheel Insert(1) Large Flat WasherSteeringBootSteeringExtensionShaftSteering WheelAdapterSeat(2) KeysSlope She

6ASSEMBLYYour new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and

7FIG. 2ASSEMBLYFIG. 3NOTE: You may now roll or drive your tractor off the skid. Follow the ap pro pri ate instruction below to remove the tractor from

8ASSEMBLY✓CHE CKLISTBEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM TH

9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning.DANGER, KEEP HANDSA